Replacement Of Cement With Quarry Dust

Introduction to Quarry-Dust as Partial Replacement ...

The investigation concludes that, as the replacement of the sand with quarry dust increases the workability of the concrete decreases due to the absorption of the water by the quarry dust. The specific gravity is almost same for both the natural river sand and quarry dust. The physical properties parameter like particle size distribution and bulking has shown high variation which can affect ...

Partial Replacement of Cement with Quarry Dust and Rice ...

analysis of this experiment gives partial replacement 25% quarry dust with cement gives the compressive strength of 41.5N/mm^2 and after that it goes on decreasing when compared to conventional without any replacement of quarry dust. It is clearly observed that addition of quarry dust up to certain extent will increase the compressive strength of concrete. Er. RAVI BHUSHAN et al …

Replacement of cement by glass powder and sand quarry …

14/08/2014· •As the replacement of the sand with quarry dust increases the workability of the concrete is decreasing due to the absorption of the water by the quarry dust •The specific gravity is almost same both for the natural river sand and quarry dust. •The ideal percentage of the replacement of sand with the quarry dust is 55% to 75% in case of compressive strength. •The further increasing ...

Strength Properties of Concrete with Partial Replacement ...

Results showed that up to 7.5 % replacement of cement by quarry dust there was no reduction in compressive strength, splitting tensile strength and flexural strength. The experimental work was carried out with M sand confirming to zone II as fine aggregate in concrete. Test is also carried out using another fine aggregate, namely bottom ash obtained from the furnace of an industry combined ...

USE OF QUARRY DUST IN CONCRETE AS REPLACEMENT FOR …

Use of quarry dust in concrete help in workability of concrete. 6. Quarry dust is a waste product from stone crushing industry and available almost free-of-cost, as partial replacement for river sand. REFERENCES [1] Study of Properties of S using ‘Quarry ust’ and ‘Fly Ash’, M.V. Rama Raju, K.V.Vivek, r.T.Siva Shankar Reddy and P. Srinivas Reddy, Pg.No. 323 to 332, International Journal ...

(PDF) EXPERIMENTAL STUDY ON REPLACEMENT OF FINE …

Similarly the percentage of quarry dust added by weight was 0, 15%, 20% and 25%, respectively the fine aggregate replacement in concrete. From this experimental results it is observed that ...

Studies on quarry dust as partial replacement of fine ...

05/05/2017· Quarry dust can be used as a finer material which can reduce the voids in concrete. 2. Up to 20% replacement of fine aggregates by quarry dust, the results obtained are satisfactory. 3. From the above results 15% replacement of quarry dust gives high Compressive and Flexural Strength. 4. By using quarry dust wastes instead of conventional ...

(PDF) Use of Quarry Dust to Replace Sand in Concrete – An ...

A. Mix proportioningTwo grades of concrete M20 and M25 having nominal mix proportion of 1:1.5:3 and 1:1:2 respectively were used by weight and w/c ratio was fixed according to the slump requirement of 60mm. For this concrete mix, quarry dust was added for replacement of sand from 0% to 100% in step of 10%. ISSN 2250-3153 www.ijsrp.org B ...

Can Quarry Dust Replace Sand in a Cement Mix ...

Quarry Dust and Cement Mix. Recent research into the potential of quarry dust in cement mixes have focused upon a partial replacement of the sand. The results to far suggest that a cement mix made of quarry dust has an increased workability, making it more flexible and easy to use, but there are doubts about its durability, and compressive ...

Partial Replacement of Sand by Quarry Dust in Concrete

International Journal of Scientific and Research Publications, Volume 5, Issue 7, July 2015 1 ISSN 2250-3153 Partial Replacement of Sand by Quarry Dust in Concrete Sumit L. Chauhan, Raju A.Bondre Assistant Professor P. I. G. C. E. Nagpur Abstract- The paper describe the role of quarry dust In the of various complex silicates are formed, causing the mass to construction of buildings and other ...

PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

replacement of cement by quarry dust with percentages 0%, 10%, 20%, 25%, 30%, and end up with 40%. M30 grade of concrete is designed according to IS: 10262:2009 code provisions. Compressive strength of the cubes were casted and cured for 7, 14 & 28 days. From the test data the results were presented in table 3 and also plot is shown in chart1. Fig 1: Compresive Strength Cube CS QD 3. …

Behaviour Of Concrete On The Use Of Quarry Dust To …

Also, the use of quarry dust as the fine aggregate decreases the cost of concrete production in terms of the complete replacement for natural river sand. This paper reports the experimental study which investigated the influence of 100% replacement of sand with quarry dust. Initially cement mortar cube was studied with various proportions of quarry dust (CM 1:3, CM 1:2, and CM 1:1). The ...

Studies on quarry dust as partial replacement of fine ...

05/05/2017· Quarry dust can be used as a finer material which can reduce the voids in concrete. 2. Up to 20% replacement of fine aggregates by quarry dust, the results obtained are satisfactory. 3. From the above results 15% replacement of quarry dust gives high Compressive and Flexural Strength. 4. By using quarry dust wastes instead of conventional ...

EXPERIMENTAL STUDY ON CEMENT BRICK WITH PARTIAL ...

compressive strength of brick made with partial replacement of quarry dust & saw dust withvarying percentage like 50 & 10, 50 & 15 . The compression strength test conducted on the specimens and the result was noted. A. Materials Used 1) Cement:- Cement is a binder, a substance that sets and hardens and can bind other materials together. The word "cement" can be traced back to the Roman term ...

The effect of quarry waste dust and reclaimed asphalt ...

In this research, a novel Hydraulically Bound Mixture (HBM) is successfully developed using waste minerals and industrial by-products to fully replace cement in road (base) and foundation materials. HBM is a mixture that sets and hardens by hydraulic reaction and usually has compaction by rolling. The materials used were reclaimed asphalt filler (RAF), quarry waste dust (QWD), plasterboard ...

(PDF) Use of Quarry Dust to Replace Sand in Concrete – …

A. Mix proportioningTwo grades of concrete M20 and M25 having nominal mix proportion of 1:1.5:3 and 1:1:2 respectively were used by weight and w/c ratio was fixed according to the slump requirement of 60mm. For this concrete mix, quarry dust was added for replacement of sand from 0% to 100% in step of 10%. ISSN 2250-3153 www.ijsrp.org B ...

Can Quarry Dust Replace Sand in a Cement Mix ...

Quarry Dust and Cement Mix. Recent research into the potential of quarry dust in cement mixes have focused upon a partial replacement of the sand. The results to far suggest that a cement mix made of quarry dust has an increased workability, making it more flexible and easy to use, but there are doubts about its durability, and compressive ...

An Experimental Investigation on Properties of Concrete …

12/12/2017· The replacement percentages of Cement with GGBS are 20 %, 40 % and 60 % by weight and 25 %, 50 %, 75 % and 100 % of Quarry Dust are used as a replacement of Natural Sand. Various combination of GGBS and Quarry Dust were prepared using M30 Grade of Concrete.The effect on these replacement materials on Compressive Strength, Split Tensile Strength, Flexural Strength, …

Quarry Dust Uses in a Construction Project - Concrete …

06/06/2016· Partial replacement of sand with quarry dust will make good concrete that is well desired in residential construction. The final product is strong bricks, slabs or tiles that are produced at lower cost compare to using sand. Saves Cost. Demand for sand from river beds is on the increase, so is getting too expensive daily, a construction project that utilizes quarrydust come at cheaper cost and ...

Partial Replacement of Sand by Quarry Dust in Concrete

International Journal of Scientific and Research Publications, Volume 5, Issue 7, July 2015 1 ISSN 2250-3153 Partial Replacement of Sand by Quarry Dust in Concrete Sumit L. Chauhan, Raju A.Bondre Assistant Professor P. I. G. C. E. Nagpur Abstract- The paper describe the role of quarry dust In the of various complex silicates are formed, causing the mass to construction of buildings and other ...

Partial Replacement of Cement by Quarry Dust | Manoj ...

Concrete technology by Ms. SHETTY. and IS 456:2000. S.Subhashini on “use of quarry dust in concrete design”.(2016) Praveen M (Feb 2014) Bijapur: Recent Trends in Replacement of Natural Sand With Different Alternatives’’(IOSR-JMCE) e-ISSN: 2278-1684, pISSN: 2320-334X PP 59-6

PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

replacement of cement by quarry dust with percentages 0%, 10%, 20%, 25%, 30%, and end up with 40%. M30 grade of concrete is designed according to IS: 10262:2009 code provisions. Compressive strength of the cubes were casted and cured for 7, 14 & 28 days. From the test data the results were presented in table 3 and also plot is shown in chart1. Fig 1: Compresive Strength Cube CS QD 3. …

Behaviour Of Concrete On The Use Of Quarry Dust To …

Also, the use of quarry dust as the fine aggregate decreases the cost of concrete production in terms of the complete replacement for natural river sand. This paper reports the experimental study which investigated the influence of 100% replacement of sand with quarry dust. Initially cement mortar cube was studied with various proportions of quarry dust (CM 1:3, CM 1:2, and CM 1:1). The ...

EXPERIMENTAL STUDY ON CEMENT BRICK WITH PARTIAL ...

compressive strength of brick made with partial replacement of quarry dust & saw dust withvarying percentage like 50 & 10, 50 & 15 . The compression strength test conducted on the specimens and the result was noted. A. Materials Used 1) Cement:- Cement is a binder, a substance that sets and hardens and can bind other materials together. The word "cement" can be traced back to the Roman term ...

EXPERIMENTAL INVESTIGATION ON PARTIAL REPLACEMENT …

REPLACEMENT OF CEMENT WITH FLY ASH AND QUARRY DUST AS FINE AGGREGATE T.SAMBA SIVA RAO#1 K. ADITYA NANDINI, M.Tech #2 #1 M.Tech Student, Structural Engineering, MVR College of Engineering, India #2 Assistant Professor, Department of Civil Engineering, MVR College of Engineering, India _____ ABSTRACT----River sand is the most commonly and widely used material …

The effect of quarry waste dust and reclaimed asphalt ...

In this research, a novel Hydraulically Bound Mixture (HBM) is successfully developed using waste minerals and industrial by-products to fully replace cement in road (base) and foundation materials. HBM is a mixture that sets and hardens by hydraulic reaction and usually has compaction by rolling. The materials used were reclaimed asphalt filler (RAF), quarry waste dust (QWD), plasterboard ...

Use of Quarry Fine as Partial Replacement of Concrete as a ...

combinations of lateritic sand and quarry dust as complete replacement for conventional river sand fine aggregate. Samples of concrete cube were made using varying contents of laterite and quarry dust as fine aggregate. The quantity of laterite was varied from 0% to 100% against quarry dust at intervals of 25%. The samples were cured for specified periods and tested in the laboratory for ...

Can Quarry Dust Replace Sand in a Cement Mix ...

Quarry Dust and Cement Mix. Recent research into the potential of quarry dust in cement mixes have focused upon a partial replacement of the sand. The results to far suggest that a cement mix made of quarry dust has an increased workability, making it more flexible and easy to use, but there are doubts about its durability, and compressive ...

Quarry Dust Uses in a Construction Project - Concrete …

06/06/2016· Partial replacement of sand with quarry dust will make good concrete that is well desired in residential construction. The final product is strong bricks, slabs or tiles that are produced at lower cost compare to using sand. Saves Cost. Demand for sand from river beds is on the increase, so is getting too expensive daily, a construction project that utilizes quarrydust come at cheaper cost and ...

Evaluation Of Mechanical And Durability Properties Of ...

and 10%) as replacement to cement and 25% of quarry dust as replacement to fine aggregate i.e., natural sand. The details of each category are described below. DETAILS OF SPECIMENS Size of cube specimen: 150mm×150mm×150mm. RCPT : 100 mm diameter discs with 50mm thick were casted Grade of concrete : M-25(for details refer Annexure-1) Water Cement ratio: 0.50 Number of specimens: 342 …

Location

CONTACT INFO